-
Brake calipers leaking
I track two 1st gen cars, and 3 out of 4 front calipers have started leaking after just a few events.
Is this a common problem? I'm not running brake ducts yet. Could excess heat cause this failure?
Thanks,
Neil
-
Neil, were the calipers new & when ?
Were the calipers old & rebuilt & when ?
Were the calipers old shit ?
Is the leak comming from the piston o-ring through the piston cover ruber boot ?
Is the piston cover rubber boot soft as rubber should be or is it hard & cracky ?
If the piston cover rubber boot is NOT SOFT the piston o-ring is also most likely not soft also.
I have raced a 1st gen for 4 years approx 30 race dates plus some open track days & never had a leaking caliper. Started with original old shit that worked well & then installed new cailpers two years ago. Will rebuild the calipers this winter because the left front is starting to hang up & not release the disc. Have always had Mazda Comp brake ducts directing air to the center of the disc.
David
CenDiv
Spec-7 # 14
-
The first 2 were rebuilt ones that I rebuilt again. One of these started leaking. I rebuilt a 3rd time, and it leaked again.
Both the other two started leaking at the same time. These two calipers are old shit that came on the car when I bought it. The boots are "hard and cracky".
I was mainly wondering if I needed to make rebuilding the calipers part of my normal car prep. It doesn't sound like that's required.
Guess I'll be getting brake ducts sooner instead of later.
Thanks!
-
Next time you rebuild them check the pistons and piston bores for burr's or scratches. I always clean mine up with a brake hone (looks like a miniature cylinder hone). Good luck.
------------------
Nico
KCRaceware (816) 257-7305
[email protected]
-
Hey guys, where do you get the rebuild kit? After 3 seasons, I have found my left front leaking. It was OK at the last race, but I took the wheels off about a month later, and the caliper is leaking around the piston..
------------------
G. Brooke Carter
Wheat Buckley Racing
# 10 Challenge Car
2003 Class Champion
Calgary, Alberta
-
Brooke...Shouldn't you be off at the beach? (of course...just watching the waves...)
I have a magazine, but don't remember the name. They did have rebuild kits listed, and I have a rear caliper that is in need of a rebuild. I'll send you an email with Ph number and name once I find the magazine.
Enjoy the winter...We just had a dumping of snow two days ago...The first snow always hurts the most.
-
Allen,
I AM at the beach, in Spain....no snow !
No race car either, but thinking about next year already...
------------------
G. Brooke Carter
Wheat Buckley Racing
# 10 Challenge Car
2003 Class Champion
Calgary, Alberta
Posting Permissions
- You may not post new threads
- You may not post replies
- You may not post attachments
- You may not edit your posts
-
Forum Rules
Bookmarks